Aerobic thermophilic treatment of sewage sludge contaminated with 4-nonylphenol.

4-Nonylphenol (4-NP) occurs in sewage sludge as a result of the breakdown of detergents which contains nonylphenol ethoxylates (NPEs). 4-NP is of environmental concern because of its toxicity to biological systems. The present paper reports results of aerobic treatment under thermophilic conditions of sewage sludge artificially contaminated with 4-NP. Experiments were carried out using three parallel laboratory-scale batch reactors operating with blank, 50 and 100 mg/l of 4-NP concentration. For the two studied concentrations up to 66% 4-NP reduction was achieved at a specific air flow rate of 16 l/(l.h) and a thermophilic temperature of 60 degrees C, within 10 days of operation. The presence of 4-NP has minor effect on the rate of sludge oxidation and the nitrogen and phosphorous content in the sludge.

Adsorption of phenol by bentonite.

The potential of bentonite for phenol adsorption from aqueous solutions was studied. Batch kinetics and isotherm studies were carried out to evaluate the effect of contact time, initial concentration, pH, presence of solvent, and the desorption characteristics of bentonite. The adsorption of phenol increases with increasing initial phenol concentration and decreases with increasing the solution pH value. The adsorption process was significantly influenced by the solvent type in which phenol was dissolved. The affinity of phenol to bentonite in the presence of cyclohexane was greater than that in water and was lowest in the presence of methanol. Methanol was used to extract phenol from bentonite. The degree of extraction was dependent on the amount of phenol adsorbed by bentonite. X-ray diffraction analysis showed that the crystalline structure of bentonite was destroyed when cyclohexane was used. The ability of bentonite to adsorb phenol from cyclohexane decreased as the water to cyclohexane ratio was increased. Furthermore, hysteresis was observed in phenol desorption from bentonite in aqueous solutions. The equilibrium data in aqueous solutions was well represented by the Langmuir and Freundlich isotherm models. The removal of phenol from aqueous solutions was observed without surface modification.

Experimental assessment of bio-reduction of di-2-thylhexyl phthalate (DEHP) under aerobic thermophilic conditions.

The reduction of organic contaminants in sewage sludge is of great importance for a further sludge disposal or agricultural utilization. Laboratory scale batch experiments were performed to assess the potential use of the aerobic thermophilic treatment technique to reduce the concentration of difficult to degrade organic chemicals. Di-2-ethylhexyl phthalate (DEHP) was chosen as a model representative of these chemicals. The effect of the sludge temperature and aeration rate on the reduction of DEHP concentration as well as on the reduction of the organic dry solid (oDS) was investigated. With a specific air flow rate of 16 m3/m3.h and a thermophilic temperature of 63 degrees C it was possible to achieve up to 70% reduction of the DEHP concentration and 61% of oDS within 96 hours. The maximum degradation of the oDS matter occurred within the first 24 hours of operation whereby only little oDS was degraded afterward. During the experiments the reactor content was routinely monitored for pH, COD, along with the ammonia nitrogen and orthophosphate concentrations.